HomeMy WebLinkAboutM09-0122NOTE: THIS PERMIT MUST BE POSTED ON JOBSITE AT
MMOFVnd
Town of Vail, Community Development, 75 South Frontage Road, Vail, Colorado 81657
p. 970 - 479 -2139 f. 970.479.2452 inspections. 970.479.2149
MECHANICAL PERMIT
ASFR
Job Address: 1730 SIERRA TR VAIL
Location.....:
Parcel No...: 210312312016
OWNER BEDNAR, KENNETH L. - HEYER -B 08/04/2009
LORI L. -JT
2794 NE 5TH ST
POMPANO BEACH
FL 33062
APPLICANT R & H MECHANICAL LLC 08/04/2009 Phone: (970) 328 -2699
PO BOX 810
EAGLE
CO 81631
License: 184 -M
CONTRACTOR R & H MECHANICAL LLC 08/04/2009 Phone: (970) 328 -2699
PO BOX 810
EAGLE
CO 81631
License: 184 -M
Desciption: INSTALL BOILER FOR DRIVE -WAY SNOW MELT
Valuation: $14,000.00
L-) � ; It
................*.>»..,. ��.... ... * *. *<.............. *.. * *.. *• " FEE SUMMARY....«.**.*.«........<#***......«««......* . * # *....<...,.. <...............
Mechanical Permit Fee --- > $280.00 Will Call ------------ > $4.00 Total Calculated Fees --- > $434.00
Plan Check ------------------- > $70.00 Use Tax Fee ------ > $80.00 Additional Fees------ - - - - -> $0.00
Investigation------------ - - - - -> $0.00 TOTAL PERMIT FEE --- > $434.00
Total Calculated Fees - -> $434.00 Payments------------ - - - - -> $434.00
BALANCE DUE --------- > $0.00
APPROVALS
Item: 05100 BUILDING DEPARTMENT
08/04/2009 JLE Action: DN NO DRB APPROVAL RECEIVED, MUST BE APPROVED BEFORE
PERMIT CAN BE ISSUED
08/17/2009 JRM Action: AP
CONDITION OF APPROVAL
Cond: 12
(BLDG.): FIELD INSPECTIONS ARE REQUIRED TO CHECK FOR CODE COMPLIANCE,
Cond: 22
(BLDG.): COMBUSTION AIR IS REQUIRED PER CHAPTER 7 OF THE 2003 IMC AND SECTION
304 OF THE 2003 IFGC AS MODIFIED BY TOWN OF VAIL.
Cond: 23
(BLDG.): BOIILER INSTALLATION MUST CONFORM TO MANUFACTURER'S INSTRUCTIONS AND
CHAPTER 10 OF THE 2003 IMC.
Cond: 25
(BLDG.): GAS APPLIANCES SHALL BE VENTED ACCORDING TO CHAPTER 5 OF THE 2003 IFGC.
Cond: 29
(BLDG.): ACCESS TO MECHANICAL EQUIPMENT MUST COMPLY WITH CHAPTER 3 OF THE 2003
IMC AND CHAPTER 3 OF THE 2003 IFGC..
Cond: 31
(BLDG.): BOILERS SHALL BE MOUNTED ON FLOORS OF NONCOMBUSTIBLE CONST. UNLESS
LISTED FOR MOUNTING ON COMBUSTIBLE FLOORING.
Cond: 32
(BLDG.): PERMIT,PLANS AND CODE ANALYSIS MUST BE POSTED IN MECHANICAL ROOM PRIOR
TO AN INSPECTION REQUEST.
Cond: 30
(BLDG.): BOILER ROOMS SHALL BE EQUIPPPED WITH A FLOOR DRAIN OR OTHER APPROVED
ALL TIMES
Permit #: M09 -0122
Project #: PRJ09 -0336
Status ...:
ISSUED
Applied ..:
08/04/2009
Issued . ..
08/18/2009
Expires . .:
02/14/2010
mechcan ical_permit_041908
MEANS FOR DISPOSING OF LIQUID WASTE PER SECTION 1004.6.
DECLARATIONS
I hereby acknowledge that I have read this application, filled out in full the information required, completed an accurate plot plan, and state that all the information
as required is correct. I agree to comply with the information and plot plan, to comply with all Town ordinances and state laws, and to build this structure
according to the towns zoning and subdivision codes, design review approved, International Building and Residential Codes and other ordinances of the Town
applicable thereto.
REQUESTS FOR INSPECTION SHALL BE MADE TWF -FOUR HOURS IN ADVANCE BY TELEPHONE AT 970.479.2149 OR AT OUR OFFICE FROM 8:0(
AM - 4 PM. /
ifure of Ow
Print Name
Date
mechcanical_permit_041908
i MECHANICAL PERMIT
Boil e-r/Furn ace ARD111cations MM include:
-Mechanical Room Uyout/Pla Dimensions
Co bustion A ir Duct Slze and LACallon
r/ lu or Vent Size
G. a Piping Plan (if applicable)
� He t Loss Calculations*
o Eq uipment Cut Sheets for Boller/Furnace
I qor req jired for same size (87U) boiler replacemenr with no system
c4anges, or snow melt
Fireplace AR2111catlans MM include-,
o . Equipment Cut Sheet"sr r Fireplaces/Log Sets
( Manufacture Manufac Info s Ing make, model & approval listing)
eject Street Address:
....... ..... * ....... ... ........ ............ ......... ....
/7 T 0 5h -TIZ
jmbjr) (Street) (Suite
omplex Name:
Office Use:
Project #: fe,3041_ 2
_f)'
Building Permit P: A QA
Mechanical Permit #:
' 1 1 \gjt
C Informatio Lot #A�� Block Subdivision: J
Company:
C¢mpa y Address: Detailed Description dWork; lyls�a« 10"flu,
City: State: 6-0 zip: F16,31
C-Pntact Name:_& �K'110oy
Contact Phone: !ZA)
(use additional sheet if necessary)
E Mail h –
Gas Piping Included
Town o Vail ontractor Rist n No. e o Gas Piping by Others
,(3 Wood to Gas Fireplace Conversion
Parcel
(Fpr pa
vl� W%
Tenan
Single-Family , Duplex Multi-Family (
Valuation for Mechanical Permit: Commercial
Restaurant Other
!al $:
. ..... I......... ..... ....... . ................ . ........ ....................... .. ............ Date Received.
br Signature (required) Boiler Location:
Interior (X) Exterior Other
Information
. .. ........
Z-1 o - 1,03 - /7- -o.1 ro fi Number of Existing Fireplaces:
I A contact Eagle County Assessors Office at 970-35 ': Gas Appliances ( ) Gas Logs ( )WoodIPellet(
-aglecouty.urs/pafle)
Number of Proposed Fireplaces:
ame:
(Commercial Properties) I Gas Appliances Gas Logs Wood/Pellet
..... ..... .
Ame: !:Type of Building:
q3 9
5( - i q ke
E C IF � W FE
AUG 0 4 2009
Apr-09
Aug. 4. 2009 12:23PM R&H MECHANICAL No-6798 P. 2
Aug. 4, 2009 12:23PM R &H MECHANICAL
y
I
c
4
O
O
0 x 0
a
c
0
v
19
d
s
N
A
la
a
No, 6798 P. 3
Aug. 4. 2009 12:23PM R &H MECHANICAL
Natural Gas
Propane Gas
105' max
105' max
105' max
50' max
105' max
50' max
Trinity Ti Series
q0"', NY ThrmelInc, quick Reference Guide
May 1st 2007
Hard water: Water with hardness higher then 100 ppm Calcium carbonate should incorporate
"water softener" prior to entering the appliance or a least clean and flush system
and refill with treated water and add additive (Use FERNOX provided with each unit)
Venting: Use: Schedule 40, Solid Core, PVC or CPVC must comply with ANS11ASTM D1784 PVC DF441 CPVC
Intake: Min. 12" above grade plus snow allowance / Increase immediately from I'i to 3" at the boiler
Exhaust: Min, 18" above intake and min. 4" off center/ Increase Immediately from 2 to 3" at the boiler
Max vent length:
Ti 100:
Ti 150:
n�Ti 200 :
Natural Gas Propane Gas
8 to 9.5% CO 9 to 10.5% CO
Natural Gas Propane Gas
4to9 "w /c 9to12 w 1c
No, 6798 P. 4
Ti 400
4" Diameter pipe = 30' max Nat. & LP
6" Diameter pipe = 65' max Nat. & LP
Count 5' equivalent for each 90 or 45" elbow
For both Nat. & LP the CO
should be less then 140ppm
Gas pressure must be taken at the Gas valve
No more then 1" drop, when fired
Ti 100 Ti 150 Ti 200 Ti 400
Low: 48 / High 240 Low; 48 / High 240 Low; 40 / High 240 Cow: 35 / High 195
Flame rod: 2.0 to 10, 0 Micro Amps (in the presence of a flame) should be read at FC1
Igniter: When the igniter is cold it should have a resistance of 40 to 100 Ohms
Fenwal: The Fenwal powers the igniter with 120V AC
The Fenwal provides 24V AC to the gas valve plug using only the 2 outside wires of
the harness. The Plug has a rectifier which converts the signal to 24V DC. When
testing on the 2 outside wires you should read +/- 15,000 Ohms. During the ignition
sequence the igniter will glow for 5 seconds. The Gas valve will then open for 3
seconds for each try; The control will try to ignite 3 times.
The Normally open pressure switch is factory set at .15 to .20
Sentry: The Sentry controls the fan speed through a 20 -39V DC signal that is sent to the
motor controller. The motor always has 120V AC'wired to it,
A -C -T : The A -C -T terminals are DRY contacts ONLY (No voltage what so ever)
codes ; ASO, ASC, ER3, ER5, ER6, (see trouble shooting in the install manual)
Aug 4. 1009 2009 12:24PM
1 Plumbing
Circ. Puma Minimum Flow
e &G Pump
Grundfos Pump
Taco Pump
Primary loop pipe diam,
291 165 120
Resistance (x1000)
Glycol: Glycol from 0 to 30% mixture is accepted. From 31 to 50% mixture, increase the
pump size by one. NOTHING above 50% mixture is allowed.
Electrical: Ensure that the polarity is correct before providing 120V AC to the boiler. The black
wire must be line voltage.
The fan motor is provided with 120V AC directly from the source.
The following charts help you find the resistance and measurement of a boiler water probe and outdoor air
probeat a given temperature.
.......... ... ...__ ......... ...............__ .._......, ___. :...____ _...__..,
Water Probe (1M ohm)
250
i
200 .�....._— _..._.... ...,_ .._...— �..... _.._ - - - --
150 - -..
100.7_ ..... _ .................. ..._....- - -_ - -- - rv.. -- ,,,.._ ................... ..................... ,,..... . ........... ._.._......... ...__..,__.... ,,, ....._.._._._.-._.....
.......... ..... i
3 60
0•�
2,264 1,304
.._._,___.,.
__..._,....� ........... .. ......._............_._._,.,... _
Moog - - -• -. - _ . _
70.000 _... ......._.......
I OD,aoo
' S0 000
'D.oW ... ......._,_....._.........._....
ao.000
2P ,000 ,..,._.,...... .. ,._.,.__ . ..__.._......
10,000 ...................,.,..
E
R &H MECHANICAL
469
No.6798
P. 5
Ti 100
Ti 150
200
Ti 400
4.5gpm
6gpm
gpm
13gpm
NRF -22
PL -30
, -36
(Min.
PL -36
UP 15 -42
UP 26 -64
26--99
UP 2699
008
009
011
0011
Min. X "
Min. 1 "
1 114"
Min. 1 112"
772
469
15
Outside 1oK probe
50
T-m( -raturo (F)
80 54
25
37 26
0
Thank you for choosing NY Thermal
curs: I Phone: I Tech Support: I Website:
7:00pm 1 800- 688 -2575 1 800- 688 -2575 1 www.nvthermal.com-
Aug. 4, 1 2009 12:24PM R&H MECHANICAL
Hee ed
f (1p,
BTU's OUTPUT:
ZFFIC4E 4Cy,
All
ALTITUDE
ONE (2
E OTAL aTUS lN fQEEDZD-,
JOB NAM
I Vv I P
r7�
�0 i
No. 6798 P. 6
SNO IV MELT
TOTAL 87Us.-
Dig, �7u
TOWN OF VAIL, COLORADO Statement
Statement Number: R090001031 Amount: $434.00 08/18/200910:34 AM
Payment Method: Check Init: JLE
Notation: 15549 R & H
MECH
-----------------------------------------------------------------------------
Permit No: M09 -0122 Type: MECHANICAL PERMIT
Parcel No: 2103 - 123 - 1201 -6
Site Address: 1730 SIERRA TR VAIL
Location:
Total Fees: $434.00
This Payment: $434.00 Total ALL Pmts: $434.00
Balance: $0.00
ACCOUNT ITEM LIST:
Account Code Description Current Pmts
-------------- - - - - -- ------------------------ - - - - -- ------ - - - - --
MP 00100003111100 MECHANICAL PERMIT FEES 280.00
PF 00100003112300 PLAN CHECK FEES 70.00
UT 11000003106000 USE TAX 4$ 80.00
WC 00100003112800 WILL CALL INSPECTION FEE 4.00
M
08 -28 -2009 Inspection Request Reporting Page 16
8:39 am Vail, CO - City Of
Requested Inspect Date: Friday, August 28, 2009
Inspection Area: JRM
Site Address: 1730 SIERRA TR VAIL
A /P /D Information
Activity: M09 -0122 Type: B -MECH Sub Type: ASFR Status: ISSUED
Const Type: Occupancy: Use: Insp Area: JRM
Owner: BEDNAR, KENNETH L. - HEYER- BEDNAR,
Contractor: R & H MECHANICAL LLC Phone: (970) 328 -2699
Description: INSTALL BQLL�R RIVE -WAY SNOW MELT
s: 328 -2699, RESCHEUD FROM 8/27/09
o: JMONDRAGON
n: Time Exp:
6
Requested Time: 09:00 AM
Phone: (970) 328 -2699
Entered By: JMONDRAGON K
Inspection Histo
Item: 200 MECH -Rough ** Approved *"
08/20/09 Inspector: JRM
Comment:
Item: 310 MECH - Heating ** Approved **
08/20/09 Inspector: JRM
Comment: SNOW MELT TUBING
Item: 315 PLMB -Gas Piping
Item: 320 ME CH - Exhaust Hoods
Item: 330 MECH - Supply Air
Item: 340 MECH -Misc.
Item: 390 MECH -Final
Action: ArAPPROVED
Action: AP APPROVED
REPT131 Run Id: 10182