Loading...
HomeMy WebLinkAboutM09-0196� NOTE: THIS PERMIT MUST BE POSTED ON JOBSITE AT ALL TIMES .� TON'N OF VAIL ' Town of Vail, Community Development, 75hSouth Frontage Road,Vail, Colorado 81657 p. 970-479-2139 f. 970.479.2452 inspections. 970.479.2149 MECHANICAL PERMIT Permit #: M09-0196 NSFR Project #: PRJ09-��IIS JobAddress: 1451 BUFFEHR CREEK RD VAIL Status . . . : ISSUED ��� Location.....: 1451 BUFFEHR CREEK ROAD Applied . . : 10/07/2009 Parcel No...: 210312102011 Issued. . . 10/08/2009 Expires . .: 04/06/2010 OWNER DYROFF, MATTHEW C. 10/07/2009 2033 11 TH ST 6 BOULDER CO 80302 APPLICANT HIGHLAND PLUMBING&HEATING, 10/07/2009 Phone: 970-328-0988 P.O. BOX 3697 EAGLE CO 81631 License: 143-M CONTRACTOR HIGHLAND PLUMBING&HEATING, 10/07/2009 Phone:970-328-0988 P.O. BOX 3697 EAGLE CO 81631 License: 143-M Desciption: INSTALL BOILER, RADIANT HEAT SYSTEM, SNOW MELT SYSTEM, WATER HEATER Valuation: $21,000.00 ........�.�.�.............<.�.,....�..�.............,.���.............��....�...�.FEE SUMMARY�.............�...,��.........�........,.�.........�.....�......���..�...�.�.......... Mechanical Permit Fee---> $420.00 Wiil Call------------> $4.00 Total Calculated Fees---> $529.00 Plan Check-------------------> $105.00 Use Tax Fee------> $0.00 Additional Fees-----------> $0.00 Investigation-----------------> $0.00 TOTAL PERMIT FEE---> $529.00 Total Calculated Fees--> $529.00 Payments-----------------> $529.00 BALANCE DUE---------> $0.00 ...<.................�........���.............,�.......��....�..�........<..�.......�.����.........��.,.......��....�,�....�.........�..�...t............,«�.�..��...,...........��...��.:.. APPROVALS Item: 05100 BUILDING DEPARTMENT 10/07/2009 JRM Action:AP .�.............�...�......�....�......�.....>.....�..�..�..<..��.�...,�..����...........��.......,,>...........���.......�.....,.�..........,.......>�...........���.�..................... CONDITION OF APPROVAL Cond: 12 (BLDG.): FIELD INSPECTIONS ARE REQUIRED TO CHECK FOR CODE COMPLIANCE. Cond:22 (BLDG.):COMBUSTION AIR IS REQUIRED PER CHAPTER 7 OF THE 2003 IMC AND SECTION 304 OF THE 2003 IFGC AS MODIFIED BY TOWN OF VAIL. Cond:23 (BLDG.): BOIILER INSTALLATION MUST CONFORM TO MANUFACTURER'S INSTRUCTIONS AND CHAPTER 10 OF THE 2003 IMC. Cond:25 (BLDG.): GAS APPLIANCES SHALL BE VENTED ACCORDING TO CHAPTER 5 OF THE 2003 IFGC. Cond: 29 (BLDG.):ACCESS TO MECHANICAL EQUIPMENT MUST COMPLY WITH CHAPTER 3 OF THE 2003 IMC AND CHAPTER 3 OF THE 2003 IFGC.. Cond: 31 (BLDG.): BOILERS SHALL BE MOUNTED ON FLOORS OF NONCOMBUSTIBLE CONST. UNLESS LISTED FOR MOUNTING ON COMBUSTIBLE FLOORING. Cond: 32 (BLDG.): PERMIT,PLANS AND CODE ANALYSIS MUST BE POSTED IN MECHANICAL ROOM PRIOR TO AN INSPECTION REQUEST. Cond: 30 (BLDG.): BOILER ROOMS SHALL BE EQUIPPPED WITH A FLOOR DRAIN OR OTHER APPROVED MEANS FOR DISPOSING OF LIQUID WASTE PER SECTION 1004.6. �....,.�..,�,�..,�....,,...........�..................,..,.,..�...........,�......�.��«.�..�...,.........................���...,���..�...,�....�........��.........�.....�......�.......,.�.......... mechcanical_permit_041908 DECLARATIONS I hereby acknowledge that I have read this application,filled out in full the information required,completed an accurate plot plan, and state that all the information as required is correct. I agree to comply with the information and plot pian,to comply with all Town ordinances and state laws, and to bui�d this structure according to the towns zoning and subdivision codes, design review approved, International Buiiding and Residential Codes and other ordinances of the Town applicable thereto. REQUESTS FOR INSPECTION SHALL BE MADE TWENTY-FOUR HOURS IN ADVANCE BY TELEPHONE AT 970.479.2149 OR AT OUR OFFICE FROM 8:0( AM-4 PM. -��_�,� �� l� -�S ���i ignature of Owner or Contractor Date ��i n I" � ti./Y� l� Print Name mech ca n i ca I_pe rm it_041908 ******************************************************************************************** TOWN OF VAIL, COLORADO Statement ************************************+******************************************************* Statement Number: R090001409 Amount: $529. 00 10/08/200910:29 AM Payment Method:Credit Crd Init: LC Notation: CC JOHN PLYMELL ----------------------------------------------------------------------------- Permit No: M09-0196 Type: MECHANICAL PERMIT Parcel No: 2103-121-0201-1 Site Address: 1451 BUFFEHR CREEK RD VAIL Location: 1451 BUFFEHR CREEK ROAD Total Fees: $529. 00 This Payment: $529.00 Total ALL Pmts: $529.00 Balance: $0 .00 ******************************************************************************************** ACCOUNT ITEM LIST: Account Code Description Current Pmts -------------------- ------------------------------ ------------ MP 00100003111100 MECHANICAL PERMIT FEES 420 .00 PF 00100003112300 PLAN CHECK FEES 105.00 WC 00100003112800 WILL CALL INSPECTION FEE 4 . 00 ----------------------------------------------------------------------------- �I I I � ��..__ _ f�.. , �._ , . . __,. . : - � � '::. �, � Development Review Coordinator _� �"� 75 South Frontage Road '�� � � � � � � � _ Vail; CO°81657 � � � � � Phone� 970-479-2128� � � ~ Fax: 970-479-2172 � . �� � - ,.,��. . . .. . �� � � � � � � Inspections: 970-479-2149 �� ty�i.t�.(+� {„` �ly+_qxq/g !� �. � ,�.: ��tl�E�R)� ! ]ZZJC . . ., ,w .�"'. .. . � f . .. ..�..sa S R...,� ..a�....z...,,.�.�u;l:,.m.r.n.m..w.�,�::nx....._a�.a.i... '.: ,., . ,,. . . TOViIN OF VAIL MECHANICAL PERMIT APPLICATION� The followinq items MUST be attached to this permit application Mechanical Room Lavout drawn to scale to include: �1��'� _ Mechanical Room Dimensions �` Combustion Air Duct Size and Location � _ Flue,Vent and Gas Line Size and Location Heat Loss Calculations _ Equipment Cut/Spec Sheets . __. ,.,.�,_�_ __..__.___._. . . . __.... .. ...... _.. . __ . . _ ... .__. ___ __ _.� .___ ___�_„_ . _ .. _.. Project Address Q �`j S � ': Project#: P�JO�I'(�' ��.....�.���I. _.�..J�lF,.,�Cr�.�. �.fP e�'t Rc� . ����. C� _ ,ra, . �.�.��.��.� �. . (�C��l-UI l5 - ; Building Permit#: Contractor Information � � ✓O'� I Mechanical Permit# �� ; Company:���Gl1 ���.M�j�'r.� d-1-letn'�'�na�c_ ` � _ . �.-... __ _�,� ..,,�.� __..�., _ .���. .�.. .�..d_. Detailed Description of Work: TnSta��all Moun1' ; I Company Address:�� �� 3�y� City:� State: C.0 Zip: �� ' �ai� �cx newe�.r�c�itrbn. unc9erF'!�� �+ea� ! Contact Name:�J� �owMe�f' ��UU� �� Uo�• �✓�.�Fl ' ContactPh:�c/U'(c/�7 4—EeIL• _� ������ ' ` E-Mail: _���y[MG��F�r���v ,�CG�c,rc.du./1 e� I�eo.fP_r rvG Uen�d-F�uP (Use additional sheet if necessary) Town of Vail Contractor Registration No: �- j�3 Complete Valuation for Mechanical Permit: '` Mechanical$ � �.�Q Cont actor Signat�uired) � ..._.._.._ . ._. . __ ---_._.._. . .�_,._._. . ...�.._. . . . _.�.. _._.... Property Information Work Class: New( ) Addition � Remodel ( ) Repair( )Other( ) , Parcel#: ��U3la(UaU1� : _:: _....�... __,.,...__.._... .: _ _.__.__ Boiler Location: Legal Description: Lot# Blk# ' Interior(� Exterior( ) Other( ) �„� ,.,. .._ ... _. .,,� .�... . . ..... . ...,�...�»,�..��.. n„M,.,,�.. ,.mra_.., Subdivision: No/Type Existing Fireplaces: Job Name: I Iv�RGS. Gas Appliances(� Gas Logs(,�jWood/Pellet O , ,...__,... .._�_._._ .,.....__ ____m__ ______�- __�.. _� ,..�-.�.. ��__..�___ ..._... .. Owner Name: /�(��}{�ew �. � /�-�,�F No/Type Proposed Fireplaces: Mailing Address:_�,�3 3 ��f�, S�� 1�7�jV���I C� Gas Appliances(3) Gas Logs(�Wood/Pellet O ` _. , ,� . ,.,.., �. . _ _� . (For Parcel#Contact Eagle County assessors Office at 970-328-8640 or visit www.eaglecounty.us/patie) �O3�ja Building Type: ; .. ........ : . .. ,..,.�A.. .. .... . ....�.. .. Single-Family�Two-FamilY� ) Multi-FamilY� ) � Architect( ) Designer( ) Engineer.Q� �1 Commercial ( ) Townhome( ) Other( ) _ Name: (�e�-L I'T�'nC�C�, S "' F�2af �aSS -�e�9vSan ; _ _ _. _ ___,_« _ _ Phone: � -�3"�- 3o�.U-Yg 33 Date Received.--� -- --- _ _ .__�,,__.,� Fax: 1-3U3 " 3� � 'G�lU4� � �� �~� �L'_.�� �,,�_� � ; E-MaiL � � �� __.r._ �_____ __.�__.__ ._a �_ .�_..�__ __. �__ � •� � , � F_.��� ._ ,`{ `l �e�3. ._....__.._ _.__.__._ . ..,.._..___.._. � � � 1 s I i T01N�a �� ����� ; ,��.__�...._ i � -.i - _,•.� r^t ..r-r y.nn.�r�F � r, °T } (. � ,s.u' 1 � ;. . y.`< ...� .S-F.y�� � . j��. �� �„�Y,��' �r�..'r`�t i �.:�r,At f r r.� , ..,1„�' •t���������i��l J t�i � r r��f�l, - ,J t � y Y) .� ���i • /,�` ' . �i� e S'w,�ie Jit x .�✓ Jf��:p � t ��.re 3 (' �.1 Y i _ •.oa� �Q��l - �re St�9e ��� � '�/� oFF �(�eS, `1� I✓'. 'il� U:vr '�f 1 �t .i I.il. - '7' � � y' J ,/�f'� � � . . . _� ..� � X � _ � � ��I � . . 5 : ,, � � ` ;a ; yx��' COM6vS1'ian � �PV . � ��:'. 3 �°' �` � ''� _ ���'� F1ve - �"'P� :;� , � � :, �� .� �, � ; ; � ; ��'" ` ; , �i r' �, 'ivr<'.'1;f.-�+�`'r�f� ,n �L �( ( IL] � i, ' ,4tt ��sri d�i H !/�.� � 'i�Ci J a�-�,o � ,,, . '�G f ` I ` ' ' �� � ' .. ����. . S,y. ' I� . �'� �f e �I . . . , :. 'r�� y11 , 1 ' � �� j,� , . . i � � � � ,�N�-: —�--- ,�, . I 7 x [5 x � o � ; ,,;,�. . :� , � " `� � � < <� . ,4�r. . � ,� h!;�, . , . • I a ' Y ?�� ' . j3„ � � • • �~r . . . � � � .. �jZ .. � . . . , � .. , . . ...� I ��.'� . . , . . . . , � , . . .. , r e� ..�...... ... . . ..... .. . -.. � ....... .. . . �' ✓ �1. .� .... . ....... ...... .- f�.r , � . , • � • , �� ' � ' , � ��� � T.O. BASEMENT SLAB ' , '.. .. , � ,: � �.,,. . , j , . ' . �yi ; 89 —4 7 8 — 8485:13' �USGS� > � ` � ----------._--- � ' �� � -.::, - ��, �- .� ,� • '�ir � , . , �,/rrl y r�, C� .�r'.'f„�f�l�f y���,��1 rr,t��r�� s ��f�i' r/�f. /�J f� 5 rs.�iI'� ' . t . ifii, .: i � �' r �. ,� � . , ' . . . � -;�.�.. . -i•f�{�r��r..��...°'.:l�r•l!'<'!Y��"n'y.:�A� '����{d: � 2 .�ats.�� ..tYi,,Si • , .,f, � �.��,1� t� , � ; .! ' - .r �`. a � � . . ' . ^^ .._:. ,,,� ' f r 1'! 7J` . � � ) � � J���. . , 5t: M � r �� : � �� �. � . •• ;�a� . , � ' �,�{f� 7. r�. . . � ' . � ' �.. . . . ' 01, - �. . . . . . . ' . . , ' ' �I:L • , � �+� ', rr,; . , .. ' , , � � ' �. . ' � , � �� . � , . �f � . . {'�' . , r�/, � . . � . • . a ��^i ;?i; 4 J' r � r.' .. ' .. � � � .' , . ?��yY,� ' �J,'� . t 3�� . � . f y�_ h.Y l^� . . . , . • . . • � . .. ' .+ . , • y., 11 l . - HC�T.TUB U.TILITY. RUONt �:�� � � �fr t C � 7�`P��C�.V' ; r.� ;,i . ,. . ,,,. : �hy . 5 , - � (CONDITlONED�SPAG�) ' 5 . � � i - .� :�� '�' CQN4RETE�LAB Wt�li iMRtOOR HEAT. `; � .. . T �.�r ,.i!.., , � . . t � . . • ��' " ' AND 2"RIGID INSUTATION � _ � ��' � . �, ft � , � � � r`,1 � °�. � i� .4f. 7lr � a n c ..i r " �P r t �. t- ri th� . . � � . ' � � .i:t :� �l��,r1t � i -� -,y �1 F:�� � �rA r�� �.ivi a:� �N �f� .. . ' ; ..�r, ,-.:' ,,d. �- � ` (ra h'1 f�y�oFF �.S s�Z� Gust;� SyS��M �c ssT� t ���. (��,`����(N �. � F;c�P��(� —� �� � s�0. �d . ��� � U ' � F.P• �� UU� � � 3/� �P. �,U. � �, �ta W n n Re9. � ] u . Q5� �' �`� S Jee. HIGHLAND PLUMBING & �. ���ns H EAT ING � � AND t. _ 5 �� R1 3� �� ~ �: � �� FER . N �. �y. � H dronics � �� � y ���x ��; '��J �. �.�, � .,.. €.x„y:': .; # : � HEAT LOSS REPORT AND . HYDRONIC SYSTEM DESIGN � � ���. � �. ,� 3-� � �- , �� � ;� ti� _ - � - �� ��� �. �� � � � ��-�� {�.� �.. �; � � �r � . ^ _ r .. . . ,. _. _ . ��� � - � � _ �, �� � . : � _ .___ �. . _ r �� . -�� . -� :. _..� � RadiantWorksProfessional Mechanical Summary Report 7/31/2009 Project Information Contact Information Project Assumptions Project Number Designed By PETE HINRICHS Outdoor Temp-15°F Project Quote Company Name FERGUSON ENTERPRISES Elevation 8350 ft Project Name DRYOFF ADDITION Phone Number 303-320-4833 Wind Speed 8 mph Designed For HIGHLAND P&H Job Type Residential EAGLE , CO (Colorado) Pump Specs Zone Name Flow Head Delta T Supply Fluid Temp Zone 1 2.3 GPM 10.9 ft 20 145°F Zone 2 0.8 GPM 6.3 ft 20 145°F Zone 3 1.5 GPM 9.9 ft 20 145°F Zone 4 0.7 GPM 3.5 ft 20 145°F Zone 5 5.2 GPM 13.6 ft 30 150°F Heated Area Descriptions Application Construction Heated Area Product Totals Zone 1 <> Room List(LIVING ROOM/TV AREA) Radiant Heating UnderFloor 681 ftZ (5)225'Lengths of 3/8" RadiantPEX+ Zone 2 <> Room List(BATH,LAUNDRY, HALL) Radiant Heating UnderFloor 251 ft2 (2)200'Lengths of 3/8" RadiantPEX+ Zone 3 <> Room List(MASTER) Radiant Heating UnderFloor 368 ftZ (3)200'Lengths of 3/S" RadiantPEX+ Zone 4 <> Room List(MASTER BATH) Radiant Heating UnderFloor 181 ft2 (2) 150'Lengths of 3/8" RadiantPEX+ Zone 5 <> Room List(PATIO) Snowmelt Slab 450 ft2 (3)225'Lengths of 5/8" RadiantPEX+ Heating Load Summary Tube Back/Edge Total Total Spacing Intensity Losses Required Provided Supp. (in) (BTU/h•ft2) (BTU/h) (BTU/h) (BTU/h) Needed Zone1 21848 22013 LIVING ROOMlTV AREA 8 32.08 2.11 21848 22013 Zone 2 9142 9947 BATH S 18.89 1.67 945 2045 LAUNDRY 8 12.07 1.50 724 2248 DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 1 of 2 RadiantWorksProfessional Mechanical Summary Report 7/31/2009 HALL 8 53 2.59 7473 5654 YES Zone 3 19016 11817 MASTER 8 51.67 7.92 19016 11817 YES Zone 4 8945 5988 MASTER BATH 8 49.42 2.88 8945 5988 YES Zone 5 67500 67401 PATIO 9 150 8.74 67500 67401 YES Project Summary Total Flow: 10.5 GPM Total System Head: 13.6 ft Boiler Load: 123720 BTU/h Total System Volume: 49 Gallons Total Heated Area: 1931 ftZ Please verify all project information for accuracy. Signature: Date: DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 2 of 2 RadiantWorksProfessional Design Report 7/31/2009 Project Information Contact Information Project Assumptions Project Number Designed By PETE HINRICHS Outdoor Temp-15°F Project Quote Company Name FERGUSON ENTERPRISES Elevation 8350 ft Project Name DRYOFF ADDITION Phone Number 303-320-4833 Wind Speed 8 mph Designed For HIGHLAND P&H Job Type Residential EAGLE ,CO (Colorado) � Design Application: Radiant Heating Supply Fluid Temp: 145°F Product: 3/8"RadiantPEX+ Delta T: 20°F #of Circuits: 5 Flow: 2.33 GPM Circuit Length: 225 ft Head: 10.9 ft Manifold Distance: 0 ft Radiant Capacity: 22013 BTU/h Required Heat: 21848 BTU/h Panel Load: 23284 BTU/h %Glycol: 0% Construction - UnderFloor JoistSpacing: 16 in SubfloorThickness: 0.75 in Subfloor Conductivity: 0.085 BTU/(h ft°F) • 0 � • Room Design Indoor Design Temp: 70 ACH: 0.5 Max SurFace Temp: 85 CFM: 56.75 Heating Intensity: 32.08 Stories: 1 Radiant Capacity: 22013 BTU/h Required Heat: 21848 BTU/h Room Construction Area: 681 ftz Horiz. Insulation R-Value: 12.82 Heated Surface Area: 681 ftz Horiz. Insu�ation Area: 681 ft' UnHeated Surface Area: 0 ftz Foil Faced Insulation: YES Banded Area: 0 ft2 Space Below: Indoor Space Tube Spacing: 8 in Banded Spacing: 0 in Floor Coverings Quantity Area R-Value Infiltration Total Heat Loss Oak-5/8": R-0.57 R-0.57 WaIIS Quantity Area R-Value Infiltration Total Heat Loss Wall 1 1 770 ft2 R-19 0 2392 BTU/h DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 1 of 12 RadiantWorksProfessional Design Report 7/31/2009 Wit1dOWS Quantity Area R-Value Infiltration Total Heat Loss Window 1 1 189 ftZ R-2 0.016 7224 BTU/h DOOI'S Quantity Area R-Value Infiltration Total Heat Loss Door 1 1 185 ft2 R-2 0.095 8385 BTU/h C@IIIngS Quantity Area R-Value Infiltration Total Heat Loss Ceiling 1 1 342.25 ftZ R-38 0 761 BTU/h Fireplaces Quantity Area R-Value Infiltration Total Heat Loss Fireplace 1 0 ftZ R-0 14 1778 BTU/h SkyllghtS Quantity Area R-Value Infiltration Total Heat Loss No Skylights 0 0 ftZ R-0 0 in2 LIVING ROOM/TV AREA Heat Loss Summary ao.s°io s.��io 8�o�o � Oak-5/8": R-0.57 e Wall 1 0.0% 0 Window 1 ��,;a� �.�, o � Door 1 0.0 /o Ceiling 1 11.6°/a 0 Fireplace � No Skylights 35.2% Zone Notes: DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 2 of 12 RadiantWorks Professional Design Report 7/31/2009 • Design Application: Radiant Heating Supply Fluid Temp: 145°F Product: 3/8"RadiantPEX+ Delta T: 20°F #of Circuits: 2 Flow: 0.79 GPM Circuit Length: 200 ft Head: 6.3 ft Manifold Distance: 0 ft Radiant Capacity: 9947 BTU/h Required Heat: 9142 BTU/h Panel Load: 7861 BTU/h %Giycol: 0% Construction - UnderFloor Joist Spacing: 16 in SubfloorThickness: 0.75 in Subfloor Conductivity: 0.085 BTU/(h ft°F) . � Room Design Indoor Design Temp: 70 ACH: 0.5 Max Surface Temp: 85 CFM: 5 Heating Intensity: 18.89 Stories: 1 Radiant Capacity: 2045 BTU/h Required Heat: 945 BTU/h Room Construction Area: 60 ft2 Horiz. Insulation R-Value: 12.82 Heated Surface Area: 50 ft' Horiz. Insulation Area: 60 ftz UnHeated Surface Area: 10 ft� Foil Faced Insulation: YES Banded Area: 0 ft2 Space Below: Indoor Space Tube Spacing: 8 in Banded Spacing: 0 in Floor Coverings Quantity Area R-Value Infiltration Total Heat Loss Tile-w/Mudset: R-0.15 R-0.15 WaIIS Quantity Area R-Value Infiltration Total Heat Loss Wall 1 1 110 ft2 R-19 0 729 BTU/h WIf1dOWS Quantity Area R-Value Infiltration Total Heat Loss No Windows 0 0 ftZ R-0 0 inz DOO�S Quantity Area R-Value Infiltration Total Heat Loss No Doors 0 0 ftz R-0 0 in= C@IIIngS Quantity Area R-Value Infiltration Total Heat Loss No Ceilings 0 0 ft2 R-0 0 inZ DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 3 of 12 RadiantWorksProfessional Design Report 7/31/2009 Skyllghts Quantity Area R-Value Infiltration Total Heat Loss No Skylights 0 0 ft2 R-0 0 in2 BATH Heat Loss Summary o.o°ia o.o°io Tile-w/Mudset : R-0.... 0.0% � Wall 1 100.0% 0.0% O NO Wi�dOws � No Doors 0.0% No Ceilings 0 No Skylights , � ,� r��; E • °� ...,, ..,..,,,�...:�,,'�'- Room Design Indoor Design Temp: 70 ACH: 0.5 Max Surface Temp: 85 CFM: 5 Heating Intensity: 12.07 Stories: 1 Radiant Capacity: 2248 BTU/h Required Heat: 724 BTU/h Room Construction Area: 60 ft' Horiz. Insulation R-Value: 12.82 Heated Surface Area: 60 ft2 Horiz. Insulation Area: 60 ft2 UnHeated Surface Area: 0 ft2 Foil Faced Insulation: YES Banded Area: 0 ftz Space Below: Indoor Space Tube Spacing: 8 in Banded Spacing: 0 in Floor Coverings Quantity Area R-Value Infiltration Total Heat Loss Tile-w/Mudset: R-0.15 R-0.15 W811S Quantity Area R-Value Infiltration Total Heat Loss Wall 1 1 60 ft' R-19 0 444 BTU/h WlndOws Quantity Area R-Value Infiltration Total Heat Loss No Windows 0 0 ftZ R-0 0 in2 D001'S Quantity Area R-Value Infiltration Total Heat Loss No Doors 0 0 ft2 R-0 0 in2 DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 4 of 12 RadiantWorksProfessional Design Report 7/31/2009 Ce11111gS Quantity Area R-Value Infiltration Total Heat Loss No Ceilings 0 0 ftz R-0 0 inz SkyllghtS Quantity Area R-Value Infiltration Total Heat Loss No Skylights 0 0 ft� R-0 0 in� LAUNDRY Heat Loss Summary o.o�ro o.o�ro - Tile-w/Mudset : R-0.... 0.0°/o � Wall 1 100.0°/a 0.0% O No Windows 0 No Doors 0.0% No Ceilings � No Skylights � '�:". �- Room Design Indoor Design Temp: 70 ACH: 0.5 Max Surface Temp: 85 CFM: 11.79 Heating Intensity: 53.00 Stories: 1 Radiant Capacity: 5654 BTU/h Required Heat: 7473 BTU/h Room Construction Area: 141 ftZ Horiz. Insulation R-Value: 12.82 Heated Surface Area: 141 ft2 Horiz. Insulation Area: 141 ftZ UnHeated Surface Area: 0 ftZ Foil Faced Insulation: YES Banded Area: 0 ftZ Space Below: Indoor Space Tube Spacing: S in Banded Spacing: 0 in Floor Coverings Quantity Area R-Value Infiltration Total Heat Loss Tile-w!Mudset: R-0.15 R-0.15 WaiIS Quantity Area R-Value Infiltration Total Heat Loss Wall 1 1 450 ft2 R-19 0 1896 BTU/h WI11dOWS Quantity Area R-Value Infiltration Total Heat Loss Window 1 1 60 ftZ R-2 0.016 2314 BTU/h DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 5 of 12 RadiantWorksProfessional Design Report 7/31/2009 DOO�S Quantity Area R-Value Infiltration Total Heat Loss Door 1 1 72 ftZ R-2 0.095 3263 BTU/h C@11111gS Quantity Area R-Value Infiltration Total Heat Loss No Ceilings 0 0 ft2 R-0 0 in2 Skylights Quantity Area R-Value Infiltration Total Heat Loss No Skylights 0 0 ft2 R-0 0 inZ HALL Heat Loss Summary 43.7% �Q o�0 0 Tile-w/Mudset : R-0... Wall 1 0.0% 0 Window 1 0 Door 1 0.0% No Ceilings o No Skylights 31.0% 25.4% Zone Notes: DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 6 of 12 RadiantWorksProfessional Design Report 7/31/2009 • Design Application: Radiant Heating Supply Fluid Temp: 145°F Product: 3/8"RadiantPEX+ Delta T: 20°F #of Circuits: 3 Flow: 1.47 GPM Circuit Length: 200 ft Head: 9.9 ft Manifold Distance: 0 ft Radiant Capacity: 11817 BTU/h Required Heat: 19016 BTU/h Panel Load: 14733 BTU/h %Glycol: 0% Construction - UnderFloor JoistSpacing: 16 in SubfloorThickness: 0.75 in Subfloor Conductivity: 0.085 BTU/(h�ft�°F) . . Room Design Indoor Design Temp: 70 ACH: 0.5 Max Surface Temp: 85 CFM: 28.81 Heating Intensity: 51.67 Stories: 1 Radiant Capacity: 11817 BTU/h Required Heat: 19016 BTU/h Room Construction Area: 368 ft2 Horiz. Insulation R-Value: 12.82 Heated Surface Area: 368 ft2 Horiz. Insulation Area: 60 ftz UnHeated Surface Area: 0 ftz Foil Faced Insulation: YES Banded Area: 0 ftZ Space Below: Indoor Space Tube Spacing: 8 in Banded Spacing: 0 in Floor Coverings Quantity Area R-Value Infiltration Total Heat Loss Oak-5/8": R-0.57 R-0.57 We11S Quantity Area R-Value Infiltration Total Heat Loss Wall 1 1 621 ft2 R-19 0 1624 BTU/h WltldOWS Quantity Area R-Value Infiltration Total Heat Loss Window 1 1 361 ftZ R-2 0.016 13754 BTU/h DOOrS Quantity Area R-Value Infiltration Total Heat Loss Door 1 1 23 ft' R-2 0.095 1042 BTU/h C@IIIIIgS Quantity Area R-Value Infiltration Total Heat Loss Ceiling 1 1 367.87 ftZ R-38 0 817 BTU/h DRYOFF RESIDENCE.rBd Copyright(c)Watts Radiant 2008 Page 7 of 12 RadiantWorksProfessional Design Report 7/31/2009 Fireplaces Quantity Area R-Value Infiltration Total Heat Loss Fireplace 1 0 ft2 R-0 14 1778 BTU/h SkyllghtS Quantity Area R-Value Infiltration Total Heat Loss No Skylights 0 0 ftZ R-0 0 in2 MASTER Heat Loss Summary 5.5% 4.3°/a 0 Oak-5/8":R-0.57 9.4% � Wall 1 � Window 1 0.0% 0 Door 1 � Ceiling 1 0 0.0% � Fireplace 72.3 /o g 5 o�p O No Skylights Zone Notes: DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 8 of 12 I i RadiantWorksProfessional Design Report 7/31/2009 • � Design Appiication: Radiant Heating Supply Fluid Temp: 145°F Product: 3/8"RadiantPEX+ Delta T: 20°F #of Circuits: 2 Flow: 0.65 GPM Circuit Length: 150 ft Head: 3.5 ft Manifoid Distance: 0 ft Radiant Capacity: 5988 BTU/h Required Heat: 8945 BTU/h Panel Load: 6509 BTU/h %Glycol: 0% Construction - UnderFloor JoistSpacing: 16 in SubfloorThickness: 0.75 in Subfloor Conductivity: 0.085 BTU/(h�ft°F) � ' e Room Design Indoor Design Temp: 70 ACH: 0.5 Max Surface Temp: 85 CFM: 14.7 Heating Intensity: 49.42 Stories: 1 Radiant Capacity: 5988 BTU/h Required Heat: 8945 BTU/h Room Construction Area: 196 ft2 Horiz. Insulation R-Value: 12.82 Heated Surface Area: 181 ftZ Horiz. Insulation Area: 196 ft2 UnHeated SurFace Area: 15 ftZ Foil Faced Insulation: YES Banded Area: 0 ft2 Space Below: Indoor Space Tube Spacing: 8 in Banded Spacing: 0 in FIOOr COVeringS Quantity Area R-Value Infiltration Total Heat Loss Oak-5/8":R-0.57 R-0.57 WaIIS Quantity Area R-Value Infiltration Total Heat Loss Wall 1 1 405 ftZ R-19 0 1544 BTU/h WI11dOWS Quantity Area R-Value Infiltration Total Heat Loss Window 1 1 140 ftZ R-2 0.016 5361 BTU/h DOOrS Quantity Area R-Value Infiltration Total Heat Loss Door 1 1 21 ft2 R-2 0.095 952 BTU/h C@11111gS Quantity Area R-Value Infiltration Total Heat Loss Ceiling 1 1 196 ft2 R-38 0 436 BTU/h DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 9 of 12 RadiantWorksProfessional Design Report 7/31/2009 Skyllghts Quantity Area R-Value Infiltration Total Heat Loss No Skylights 0 0 ftz R-0 0 inZ MASTER BATH Heat Loss Summary 11.5°/a �5.3% � Oak-5/8":R-0.57 �Wall 1 64.7% 0.0% 0 Window 1 ��`�' �� o � Door 1 0.0 /o Ceiling 1 0 No Skylights 18.6% Zone Notes: DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 10 of 12 RadiantWorks Professional Design Report 7/31/2009 • Design Application: Snowmelt Supply Fluid Temp: 150°F Product: 5/8"RadiantPEX+ Delta T: 30°F #of Circuits: 3 Flow: 5.23 GPM Circuit Length: 225 ft Head: 13.6 ft Manifold Distance: 0 ft Radiant Capacity: 67401 BTU/h Required Heat: 67500 BTU/h Panel Load: 71334 BTU/h %Glycol: 50% Construction -Slab Slab Thickness: 4 in Thickness Above Tube: 2 in Slab Conductivity: 1.2 BTU/(h ft�°F) ' ` �1 e Room Design Max Snowfall: 16 in Shielding: Suburban Snow Free Area Ratio: 1.0-(Class III) Sensible(BTU/h) Melting(BTU/h) Evaporation Atmosphere Total(BTU/h) (BTU/h) (BTU/h) Startup 7.4 41.3 45 113.8 207.5 , Steady State 0 0 0 Idling 76 76 Room Construction Area: 450 ft2 Exposed Slab Perimeter: 0 ft Heated Surface Area: 450 ftz Perim. Insulation R-Value: 5.21 UnHeated Surface Area: 0 ftz Perim. Insulation Length: 0 ft Banded Area: 0 ftZ Horiz. Insulation Area: 450 ft2 Tube Spacing: 9 in Horiz. Insulation R-Value: 5.21 Banded Spacing: 0 in Floor Coverings Quantity Area R-Value Infiltration Total Heat Loss New Layer(Top Layer) R-0.31 Zone Notes: DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 11 of 12 RadiantWorks Professional Design Report 7/31/2009 Project Heat Load Summary —a��io Zone 1 0 Zone 2 6% � Zone 3 � Zone 4 �;_- � Zone 5 ���,� 15% 13% ;'r$:`�,"` 19% Project Notes: We assume the following information for this job: Ceiling R-values- Wall R-values- Window R-values- Door R-values- Ceiling heights- Floor coverings- Job location- Elevation- "We assume that all slab areas use the"Barrier" or equivalent insulation around all perimeters. Install tubing under all tubs and showers. *We assume supply and return runs to be ran in the most direct manner possible. Please verify all project information for accuracy. Signature: Date: DRYOFF RESIDENCE.rad Copyright(c)Watts Radiant 2008 Page 12 of 12 � � � ; w � ' � �� � n .. � , � �wr y ; _ , { % /� � }: � . .. .... . .. � �. . , : . . .. . . ... .. � , � � � �' " �� � ... .. .. � � , � . .� . � . .. �mwv . _ . .... . .�i.:,. ��. . . � ' :�;..... ...:...... �.,� r� .... � y ' 3� , ., .� .� � ..' . � , � � � �� � ..__ _I � t _ <� �.. � � �� �� � � � — � � � � � ��� � ` � � � � � 1 � I � � 1 � � � � ��� � �� s _ �` ✓ 96% Efficiency [Louu temperature appiicadonsl , , , ✓ Fuily Modulating � � � -�✓ Digitai Display � ; . � rv ✓ Direct Vent with Standard Schedule 40 PVC s k .;� ; ✓ Minimal Space Requirements ' '_✓ Naturai Gas or Propane � __ � f Low NOx ✓ Nigher Waier Volume than ��� � , s � Competitiue Units �r�� � :;4 — � ; a� Low Pressure Drop ; M.._.-- _� , ,�� � �✓ Quiet Operation � G n,���P: �r _ � _ ;;� , �� �x �,.. i , , ;, -� _ �� . �,, ���� � , � � � � � -� ` � -��.;�. � . . � � � � -- �.r�� � � , , ;�,��.� �. .� . �' � � � ., � r� - Y�. � : � � .;::� �. _ l � , � _ �, � �� � � ����� ��' `� � � . � ���, � � � � : � � ,;��r �.�� ` '�r* . � 1��� �� ���� �, e>�,.,_.,. �. , .�,��_ _ ,w ,. _.�.. � �e _W .. . rt , .. �a., ; f k MCBA Control The Prestige uses a microprocessor � Digital display module , •j �.,���������� ; electronic control module that automati- � Ignition control u �s�: � cally adjusts blower speed and gas flow � O eratin control - Illli!�I�'I° � � P 9 �i�ii��i��siriiil�iii�i� �����- ' rate to modulate boiler firing rate to � High temperature limit protection � �. � �, \ @�� closely match boiler output for space � Modulating temperature control ��!��—`��-_ :m 1, h e a t i n g o r D H W h e a t i n g d e m a n d. T h e � ik � Low water protection , �� module responds to signals from the � i ' � Outdoor reset ; '� '�� room thermostat, supply and return � � � Domestic hot water priority w a t e r t e m p e r a t u r e s e n s o r s, f l u e t e m p e r- ature sensor, domestic hot water aquas- � Two pump controls (Heating and DHW) tat and outdoor temperature sensor. � Boiler freeze protection Stainless Steel Premix Burner Assembly High grade stainless steel burner uses pre-mixed air and gas providing a 25% to 100% modulating firing rate. The Prestige burner features a long life, quiet operation, reliable spark ignition, ��. }� and clean combustion for low NOx applications. � � �s.�� " � � =E � � "� 'µ� , , �, The blower, gas valve and venturi provide the proper gas and air � � � < mixture for precise combustion. The blower pulls in air and gas �, ' " �..�` �. �' through the venturi. The air and gas mix inside the blower and �`�* �,� ,� are pushed into the burner for combustion. The gas valve sens- �' � _.�� es suction from the blower and allows gas to flow only if com- �`�� �` bustion air is flowing and proper combustion is achieved. Control Panel with �igital �isplay .,._ - .� A 4-digit user's Interface Module is provided to display ��' ' system operating status and fully adjustable parame- � _ �-*� �`' � � � ter values as well as diagnostic codes for easy trou- � � � � � bleshooting and optimum system performance. � f � , - ���. � � v..�� G� � _ ._ � .�. �. . .N,u� r .x.a ,�_� ,,. .�.,,�u , . .-_:, Prestige Solo 'I 'I O Exploded View Burner � MCBA Controi Module _� on hinged panel �� ,. ._._ . -— � — � << � � ` ( �. Heat Exchanger ' ; '; �i'��'� �_1 . i . ' _ _ ..__ �'I . � �""__ t i Insulation Lining � -- __ ��;� � � � ,; � � ; i � i '`�{� , _ � ' I � I I ' � � '. � � .,� { ' '' ( � ` ' � ' i _ �- °° , �, C ; _— _1-- � TM �i.�wr�. �' i /. ;' ? U � ) 3 I Flue wa s ' Control Display—_,,` y „,, � -�`�= Condensate drain assembly The components of the Prestige are easily accessible for serviceability. The Solo 175 & 250 are shipped less the circulator. Stainless Steel Heat Exchanger R uoique, highlq 2f f ici2�r � Unique geometry:3 consecutive baffles direct water flow ���: hear ezchaoger is ar rhe �, �`-�`�.� '' ��r, through the exchanger and around the combustion chamber. hearr of the Pr2stige. � �; ��f�='� f � ,;���� � Highest water content in the industry 1 ```� f"���°� � �`#� -Stable temperature control .� .��,. ,,- ..r..i � ,}�f, ;�� ,, r J ��J :} - Less sensitive to water flow :� � 4 3 9 G r a d e S t a i n l e s s S t e e l. U n p a r a l l e l e d r e s i s t a n c e t o c o r r o s i o n .� � � ��� � � � I� � Less sensitive to sludge �� � � ' �< � � Self cleaning: condensate washes combustion residue away � � � � when streaming down the tu bes resul ting in a cons tan t �� � efficiency and reduced maintenance. � � Low pressure drop � � � � � � � � � � Mw , `� , � � � � "sa +9s xa fi t f � 7�y ,7 k Y�,� ,c t3 d ,x a ��#� � '�'���'z x ��.� � z r r ��� ^,'�� ��f���y��"� 4�����ea"�*'°� � �. 5� h 4 t( € a , . ......... ...��,.. .. ��'���;�'��{?�s� a ���'�"�a� ��`�`��"�''���,��'z�,'��tt�������„�;;s�"�'�� .�i �� s a k*�,r�,.t� -�'3 �,`�z.„� -�r � "t'� �,` '�. x� t � �vt � � ��a ,�c h� �a �y � � ��S t k # 3' � �. � §� .�,€��'"� {J ,�"`,r'� * �' ; � �x�' t r # a�r.. �,..: � t3��k,�,�`��."�'�Ft�,���7� r�^�,�.»�` � �-�`r F�a s�5.� ��€� � �� t i"§N �� �;�� .; � ' . s t ,, � �,t- ? -t, . 3��'�-1� , .�, � .:_. .. �t,�?.�tirr..i�. �*�r;�''�"�.h�,,, .� ... ._��. .,...� r ..� . ... .... . a m�,_... . .. .�. _......, , _, �,,� .� ., _..,. , z n.. , ."", . `''.,,...,. Performance Specifications ��r v � a �� :: � ;? E�$fl Arr � �2Y :'�";,;, � + .,-rt ,y;,�� ,�,�' .��.-`��`.s'� s r���iCS '�' t �.,.+..� . '$t 'z . . . � �` . j . .� .� �" �, . .a.���. ? �,.:., ,. _ �. ...,, ssx� . . . . . ....__;_.. ...� ,: �r._...c..,.; ' �... . ":._.t . .... . .. �d„�eE _. ,:.,b, .., .,°. Solo 110 Natural Gas 30 to 110 93% 103 gg 2.5 Solo 110 LP Propane Gas 30 to 100 93% 93 79 2.5 Solo 175 Natural or Propane 50 to 170 92% 157 134 4.6 Solo 250 Natural or Propane 65 to 245 92% 226 192 4.1 Connections / Dimensions / Oat� � ��w .:���, ,,� �. � 4�,., a�, m;�.� a" -aa��. � �� �- ._ .,.... .. ,.. . . k_. Solo 110 Natural Gas/Propane 1" 1/2" 3" 16"x 20"x 35 1/2" 106 Solo 175 Natural Gas/Propane 1 1/4" 3/4" 3" 16"x 20"x 35 1/2" 131 Solo 250 Natural Gas/Propane 1 1/4" 3/4" 3"or 4" 16"x 20"x 35 1/2" 142 _, __ _. ___ . � The Prestige, combined with a � Limited 10 year warranty Phase III Smart Indirect Fired I � Stainless steel heat exchanger Water Heater, will provide effi- � Outdoor temperature sensor cient, reliable heat and an abundant supply of domestic � Stainless steel burner hot water. The boiler is "indi- , � Negative pressure gas valve � � rect ready" with a seperate 1" � 30 psi relief valve `` " � supply connection (110 only). � Flanged Grundfos 3-speed UP15-58 system circulator (110 only) , � Drain valve � Pressure gauge � 1� Condensate drain assembly � 24 V terminal strip with removable _ jumpers for manual reset or automatic reset of external controls Op���s� ��..,.:_ � NTC temperature sensors on the boiler supply/return and flue • Floor Stand •Condensate Neutralizer Kit • Concentric Vent Kit • 5 and 10 Year Parts and Labor Plans Triangle Tube reserves the right to make product changes or improvements at any time without notice. �.- ... _ - _ __ - - -- __ ___ ___ _. _ _�,:�----- � /�PT�F'Fo Freeway Center- 1 Triangle Lane Biackwood, NJ 08012 Member of j �so soo> > Tri�ngleTu�e Tel: (856)228 8881- Fax: (856)228 3584 �S\NOPP/ ffor w�,teY rp��G�rs E-mail: info@triangletube.com - http://www.triangletube.com � 2005-23 Prestige Solo Lit.-Revised 11/06 Group _ _ �;� r, � — �. � �� ��� � ��7,� .� � ,i� �� ��� ,a�. . � ��� , _ � � � ��`� � � � �� ����.��,���`;"-� �� � � .� � � � �� � �� , ���� "� � �"� � � ���� � �� TM $.�� �. �} ��=a $ :; �� �� �� �^ � �� � ��� p2 : � 1 i v�,,� , , �.��� � > > . � u�.�n�.� „ �� `t . . . . . �����Y���'��4��� ,F� -, `r.� „�te � ,� y�,'��� ..�'�.�� p�,Y, �.::� , , � t� ts,�, 4,.�w?�y �" �t:�"cs l�p'a�',���'�v` �`;5 {�'�`T � f :��direct Fired �+{ r� ( {�� X{ � e 3 Fp � , �� �iJ����.i� 1 x:�.�., C�r�,"',�C D�`�,'M�ry,£7 � . � �`x�t������,;:'";��-ra. ���� � `��� ����.������ �������. ; ' _� ,� + y� �s�r r� y� .��s�,.,+� �. =� � ` U#�+ ��� tt� ��e'��� ��� ���� �r � ,�� ��,�� x�r t�1 � �► � . ��� � � � ..... � ���r��� ' ��`����_ , .� � , , � � � �� �" af F�ol�uret�����irri �� tr�sutati�r� �� , Self `� ���3�e����t�� k � � �� ��������$ f # Heat ������er �', ss �s��� ���dt�Zt' # ; , ... ..����". r� ,� .:�; , . ,.:• •' `' � � � ����� � �� �. ..� �._;. _, ��� . ,�3'�����1'��1�lt'�.'' ��`t�� 111 � � � � ��x �� '��1� ��US�t'�.. ����1 � ,�� � r ����� _ � $ �IZBS t� tih�8 �'t`�31"�3-� Construction Specifications SMART Series F H � L M G � i ►` �/ A. Inner stainless steel tank i B. Outer steel tank C. 2" Polyurethane insulation D. Boiler water connection E E. Boiler water connection F. Hot water outlet q _ G. Cold water inlet � K H. Auxiliary connection g I. Thermostat control J. Plastic jacket � p K. Thermostat remote sensing bulb L. Air vent connection � � M. Electrical wiring plug � E � � T �s <I31E0 0 Smart Series is tested in accordance with the standard(ANSI/UL-174) (CAN/CSA-C22.2 NO. 110-M90)and is certified by ETL. Superior Design"Tank-in-Tank"Technolo9y Superior Heat EMChange Surface Area A ,,, � Self Cleaning/Self-descaling The domestic storage tank is � constructed of stainless steel and is The inner, domestic tank is suspended surrounded by boiler water in the outer within the outer tank so it is free to tank, resulting in a full "wrap around" expand and contract as the pressure heat exchanger. varies during hot water draws. It's superior heat exchange surface Moreover, its corrugations amplify the (typically 1.5 to 2.5 times larger than a movement and prevents the lime build traditional coil) produces a larger °-� up on the heat exchanger; thus volume of hot water in a short period of •�. maintaining its performance during the time. Thanks to this fast recovery, the _ „„��, " SMART Series life span. storage capacity can be reduced, '--- — resuiting �n a reducea tnermai ioss. � Anti-Bacteria Growth/Maintenance Free '.,$..d_ ..... _-. Stainless Steel Tank Construction --=-��" , � ' The "Tank-in-Tank" design allows us to The inner domestic storage tank is ��R � store domestic water at higher tempe- constructed of durable, corrosion �„ ratures preventing bacteria growth. resistant stainless steel. �,:;: Additionally, contructed of high quality ��T � stainless steel, SMART Series does not require a protective anode. Optimal Insulation SMART Series, is insulated with 2" of �"' ., w.. injected polyurethane foam, resulting in � a stand by heat loss of less than 1°/Hr. � Product Specifications � as- M � - a �z :� a� !• � a �a !o : • e s ��. .t: c n ard .e. :- s s. e: °o !a.. Smart 20 22"dia. 32" 1" 3/4" 3/4" 22 5 11 100 Smart 30 22"dia. 38" 1" 3/4" 3/4" 28 5 13 115 Smart 40 22"dia. 46" 1" 3/4" 3/4" 36 6 16 135 Smart 50 22"dia. 57" 1�i4" 3/4" 3/4" 46 8 20 165 Smart 60 22"dia. 66" 1�ia" 3/4" 3/4" 56 8 24 190 Smart 80 26"dia. 61" 1�i2" 1�i2" 1�i2" 70 14 28 271 Smart 100 26"dia. 78" 1�i2" 1�i2" 1�i2" 95 25 36 362 Smart 120 32"dia. 72" 2�� 1�i2" 1�i2" 119 43 42 479 (')This fitting can be used as a return connection if circulated domestic water is required or can be used as a connection for the T&P Relief Valve. Performance �m- a s m � „� � � � � Conditions: ' �`��� °t �" � � -200°boiler water supply ``: �`'; - g0°temperature rise Smart 20 79,000 120 105 35 Smart 30 87,000 140 115 40 Smart 40 112,000 180 150 50 � Smart 50 140,000 220 185 65 Smart 60 270,000 410 360 100 Smart 80 300,000 460 400 125 Smart 100 337,000 525 450 150 Smart 120 420,000 650 560 190 How it Works Smart Series operating cycle � � � � When the thermostat in the inner tank calls for � �� heat, the boiler and circu- =�-�—� lator start. Boiler water is circulated around the outer tank and heats the domestic water in th e inner tank. After transfer - . . . III � � nng its heat, boiler water is ` returned to the boiler to be re-heated. When the ther- � �� mostat in the inner tank reaches its pre-set mark, Cold Start Recovery Start Recovery Completed In Service the boiler and Cit'CUlatOr (pump off) (pump on) (pump off) (pump on) Shut Off. Energy Efficiency . � The Stainless Steel Indirect Fired Water Heater is heated by the hot water from your boiler. As your home is being heated, your domestic hot water is being heat- ed at the same time, thereby, consuming less fuel and conserving energy. Combine this with a recovery rate that is up to three times faster than conven- tional gas or electric water heaters, and The SMART Series Indirect Fired Water �_� � Heater heats more hot water with less fuel for the energy conscious consumer. �� °A ;: Long Term Dependability ,�� {' � ,� ��. The average life span of a SMART Series Indirect Fired Water Heater exceeds 20 �., � years! That is two or three times the average life of a conventional gas, oil or electric � ,.; water heater. Installation _ _ __. - - __ __ __ -- - _ . 9 lo SMART Installation with I Recirculation Loop ' � Prestige Condensing Boiler I ' 4 I i Prestige 5 ', � i ' � Mixed Water 8 � Optional 12" To dishwasher* Heat Trap 10 1� 10 Loop Heating 4 Cold Domestic � System Supply 3 g Water � Heating 6 3 � System Return 5 Boiler Return 7 I Cold � Water Fill I� 3 11 �'�� 7 ! �'�, Boiler supply 2 � 3 4 `� 2 SMART Indirect Water Heater � (*) Optional devices may be required by local codes. I , 1. Temperature & Pressure 5. Flow Check Valve 9. Pressure Relief Valve Relief Valve 6. Backflow preventer or 10. Air Vent ' 2. Drain pressure reducing valve(*) 11. Automatic Fill Valve ' 3. Shut -off Valves 7. Expansion Tank i 4. Circulator 8. Mixing Valve Member of G�pTIF��O � IS09001 '� One Triangle Lane • Blackwood NJ 08012 + = ooa �� Trianyle � sqvppP° p 856.228.8881 f 856.228.3584 www.triangletube.com Grou� � 2009-8 Sman Lit.2/12J09 ` - ��QC/�� 06-28-2010 Inspection Request Reporting Page 10 9:07 am Vail, GO - Citv Of Requested Inspect Date: Monday,June 28, 2010 Assigned To: CGUNIVN Inspection Type: MECH Inspection Area: JRM Site Address: 1451 BUFFEHR CREEK RD VAIL 1451 BUFFEHR CREEK ROAD A/P/D Information Activity: M09-0196 Type: B-MECH Sub Type: NSFR Status: ISSUED Const Type: Occupancy: Use: Insp Area: JRM Owner: DYROFF, MATTHEW C. Contractor: HIGHLAND PLUMBING&HEATING,INC Phone: 970-328-0988 Description: INSTAL�BOILER, RADIANT HEAT SYSTEM, SNOW MELT SYSTEM,WATER HEATER Requested Insaection(s) Item: 390 MECH-Final Requested Time: 10:30 AM Requestor: HIGHLAND PLUMBING 8 HEATING,INC Phone: 970-328-0988 Comments: 390-1967 Assigned To: CGUNION Entered By: JMONDRAGON K Action: Time Exp: � � �� / � � � � \ Inspection Historv Item: 200 MECH-Rou h 01/06/1� Ins ector: CG Action: CR CORRECTION REQUIRED Comment: PA�TIAL FOR BOILER VENT/INTAKE PVC PIPES ONLY 1 EXTERIOR TERMINATIONS TO BE 5'ABOVE GRADE MIN. 2 NEED BOILER MANUAL TO CHECK TERMINATION DETAIL, SEPARATION EQUIREMENTS 31 AIR INTAKE DUCT NEEDS MIN. SEPARATION FROM EXHAUST PER IMC AND BOILER MANUFACTURERINSTRUCTIONS Item: 310 MECH-Heating Item: 315 PLMB-Gas Pipin�g Item: 320 MECH-Exhaust Hoods Item: 330 MECH-Supply Air Item: 340 MECH-Misc. Item: 390 MECH-Final REPT131 Run Id: 11631