HomeMy WebLinkAboutREPORT_TAB_18431 Report, Vail Restaurant (La Nonna), 11-27-18.pdf ,.:M i
.y.
Ii 1 4
IIi
.:1
Y
I,♦
♦i,
S.
AIR-RIGHT, INC.
Precise.Accurate.Reliable.
T.A. B . Report
Project:
La Nonna
100 E Meadow Drive, Unit 24
Vail, CO
Prepared for:
Climate Control
Report issue date:
November 27, 2018
Air-Right, Inc.
Project Number
18431
747 Sheridan Blvd, Unit 8BAIM
R R Lakewood, Colorado 80214
I'tI E . V V PFax:(303)232 1238hone:(303) 5
1 TEST1104.P.DAEITIM PAD 9AL.NCO BUREAU
0 e-mail:henry@air-rightinc.com
THE P-ROF[BiIONAL,3 CHOICE'
•
...,..::„:„.., .;..::.z
.:::. ...„...::.
rii‘
...4...160_,:.
•.:.::....,,.::•:
AIR-RIGHT, INC.
Precise.Accurate.Reliable.
Test, Adjust, and Balance Report
The data presented in this report is an exact record of system performance and was obtained
in compliance with NEBB procedural standards. Any variance from the design requirements shall
be documented in this report.
The results shown and information presented in this report is certified to be accurate and
complete to the extent possible by the equipment and procedures used to balance the project.
The final air distribution system measurements are in compliance with NEBB Procedural
Standards for testing, adjusting, and balancing of environmental systems, and the project
specifications.
CERTIFIED BY: �, � Date: November 27, 2018
Air-Right, Inc. warrants the air system presented in this report is operating at the specified
levels as shown in this repot at and only at this time. Air-Right, Inc. makes no other warranties,
stated or implied, concerning the continued performance, operation, or safety in the use of this
equipment past this this time.
wii ht, Inc
NEBB Air and Hydronic Systems Certified Professional:
Timothy A. Topping NEBB Number 2589 TIMOTHY A.TOPPING
Certification Expiration/renewal date: 03/31/20 CERTIFICATION
2569
EYp.3/31/20:� web
'7/\z,....,,_,./ VO,'Of11C� �\
NE I BB
Air-Right, Inc. 747 Sheridan Blvd. Unit 8B, Lakewood, CO 80214, Phone: (303) 232 5145 Fax: (303) 232-1238
•'r
10.00,
AIR-RIGHT, INC.
Precise.Accurate.Reliable.
Table of Contents
Document Page
Cover page 1
NEBB TAB Certification 2
Table of Contents 3
Abbreviations 4
MAU Report 5-6
Fan Unit Report 7-10
Drawings 11-12
S
a.....::: ..:.,:
...
2•
:,...,
•.1
AIR_-RIGHT, INC. ABBREVIATIONS
Precise.Accurate.Reliable.
ACU Air Conditioning Unit HWP Heating (Hot) Water Pump
AHU Air Handling Unit Hx (HX) Heat Exchanger
AMP(S) Amps Hz (HZ) Hertz
ATMOS Atmosphere MAU (MUA) Make-Up Air Unit
BAS Building Automation System Max Maximum
CD Ceiling Diffuser Min Minimum
CFM Cubic Feet per Minute NA Not Applicable
CRAC Computer Room Air Conditioner NAC No Access
CWP Chilled Water Pump NG None (Not) Given
DD Direct Drive No Number
DDB Dual Duct Box OSA Outside Air
dP (DP) Differential Pressure PD Pressure Drop
EF Exhaust Fan PDU Pool Dehumidification Unit
EFF Efficiency PF Power Factor
El Exhaust Inlet PH Phase
ERV Energy Recovery Vessel PSI Pounds per Square Inch
FCU Fan Coil Unit RF Return Fan
FFU Fan Filter Unit RI Return Inlet
FL Amps Full Load Amperage RPM Revolutions per Minute
FLR Floor Register RTU Roof Top Unit
FPM Feet per Minute SF Service Factor
FPVAV Fan Powered Variable Air Volume SD Supply Diffuser
FR Frame SF Supply Fan
FT. HD. Feet of Head SWR Side Wall Register
FUR Furnace TSTAT Thermostat
GPM Gallons per Minute VAV Variable Air Volume
HP Horse Power Volt Voltage
HRV Heat Recovery Vessel VP Velocity Pressure
i•�, •4ti
TT'
AIR-RIGHT, INC.
P•ccia cvry Le1elivbe,
LOCATION: PROJECT NUMBER: CONTACT:
18431 Jerald Bell
MAU
MAU-1
UNIT DATA
Manufacturer CAPTIVE AIRE Serial No. 3501343
Model No. A3-D.500-24D
MOTOR DATA
Manufacturer TECO Rated Volts 230/460
Frame 213T FL Amps 19.1/9.5
Horse Power 7.5/5.5 Service Factor 1.15
RPM 1756 Power Factor NG
Phase 3 Nominal Efficiency 91.0
DRIVE DATA
Motor Drive DIRECT DRIVE Motor Bore
Fan Drive Fan Bore
Number of Belts Belt Size
STARTER DATA
Manufacturer FACTORY Range
Model Rated Amps
Size Tested at(Hz)
TEST DATA
Design Actual % Design Actual
Supply 5500 CFM 5575 CFM 101 Actual RPM DD RPM
Volts T1-T2 212 Volts Amps T1 3.3 Amps
Volts T2-T3 211 Volts Amps T2 2.7 Amps
Volts T1-T3 210 Volts Amps T3 3.0 Amps
MAU-1 2018-11-27
.Ii:`"
-. 4
1
Y
AIR—RIGHT, INC.
Plec i e1Wcv riiie1e lig be,
LOCATION: PROJECT NUMBER: CONTACT:
18431 Jerald Bell
STATIC PROFILE
Fan In -0.44 in.H2O Fan Out 0.85 in.H2O
MAU-1 1 Summary
SUMMARY
Name Type Size Design CFM Prelim CFM Final CFM %of Design
Outlet-001 PSD-1 24x24 360 160 355 99
Outlet-002 PSD-1 24x24 360 164 345 96
Outlet-003 PSD-1 24x24 360 170 360 100
Outlet-004 PSD-1 24x24 360 183 365 101
Outlet-005 PSD-1 24x24 600 750 590 98
Outlet-006 PSD-1 24x24 600 667 600 100
Outlet-007 PSD-1 24x24 600 850 600 100
Outlet-008 Hood 1575 1635 1635 104
Outlet-009 SG-1 10x6 200 374 215 108
Outlet-010 SG-1 10x6 200 353 215 108
Outlet-011 SG-1 10x6 200 497 210 105
Outlet-012 SG-1 6x6 85 80 85 100
Totals 5500 5883 5575
MAU-1 2018-11-27
i•�, •4ti
TTS
%MO
AIR—RIGHT, INC.
P•cc,sc.Accvrcie.Ba liv ble.
LOCATION: PROJECT NUMBER: CONTACT:
18431 Jerald Bell
Exhaust Fan
KEF-1
UNIT DATA
Manufacturer CAPTIVE AIRE Design CFM 5550
Model NAC Design Static 1.3
Serial Number NAC
MOTOR DATA
Manufacturer NAC Frame
Motor HP Volts
RPM Amps
Phase Power Factor
S.F. Nom.Efficiency
DRIVE DATA
Motor Drive NAC Motor Bore
Fan Drive Fan Bore
No.Belts Size
STARTER DATA
Manufacturer LENZE Set at(Amps) 7.7
Range 0-60 VFD set at 60 Hz
TEST DATA
CFM 5512 Amps T1 NAC
RPM NAC Amps T2 NA
VoltsT1-T2 NAC Amps T3 NA
Volts T2-T3 NA Fan In NAC
Volts T1-T3 NA Fan Out ATMOSPHERE
KEF-1 2018-11-27
.li•�
AIR—RIGHT, INC.
P'C S i5e.AGGVr ie.fl9II9b ei
LOCATION: PROJECT NUMBER: CONTACT:
18431 Jerald Bell
NOTES:
UNIT DATA
Manufacturer
NO SAFE ACCESS TO MOTOR.SITS ON PITCHED ICY ROOF
TEST DATA
CFM
8.75AK X 125 FPM=1085
19.25AK X 230 FPM=4427
KEF-1 2018-11-27
i•�, •4ti
TT'
_.11111110
AIR-RIGHT, INC.
P•cc,sc.Accvrcie.Ba liv ble.
LOCATION: PROJECT NUMBER: CONTACT:
18431 Jerald Bell
TEF-1A
UNIT DATA
Manufacturer PANASONIC Design CFM 140
Model FV-15VQ5 Design Static 0.15
Serial Number 708
MOTOR DATA
Manufacturer ALL INFO TAKEN FROM MOTOR HOUSING Frame NG
Motor HP NG Volts 120
RPM NG Amps 0.24
Phase 1 Power Factor NG
S.F. 1 Nom.Efficiency NG
DRIVE DATA
Motor Drive DIRECT DRIVE Motor Bore
Fan Drive Fan Bore
No.Belts Size
STARTER DATA
Manufacturer NONE Set at(Amps)
Range VFD set at
TEST DATA
CFM 145 Amps T1 0.1
RPM DD Amps T2 NA
VoltsT1-T2 120 Amps T3 NA
Volts T2-T3 NA Fan In ATMOSPHERE
Volts T1-T3 NA Fan Out NAC
TEF-1A 2018-11-27
i•�, •4ti
TT'
_.11111110
AIR-RIGHT, INC.
P•cc,sc.Acc v rc ie.Ba liv ble.
LOCATION: PROJECT NUMBER: CONTACT:
18431 Jerald Bell
TEF-1B
UNIT DATA
Manufacturer PANASONIC Design CFM 140
Model FV-15VQG1 Design Static 0.15
Serial Number 80313
MOTOR DATA
Manufacturer ALL INFO TAKEN FROM MOTOR HOUSING Frame NG
Motor HP NG Volts 120
RPM NG Amps 0.18
Phase 1 Power Factor NG
S.F. 1 Nom.Efficiency NG
DRIVE DATA
Motor Drive DIRECT DRIVE Motor Bore
Fan Drive Fan Bore
No.Belts Size
STARTER DATA
Manufacturer NONE Set at(Amps)
Range VFD set at
TEST DATA
CFM 150 Amps T1 0.1
RPM DD Amps T2 NA
VoltsT1-T2 120 Amps T3 NA
Volts T2-T3 NA Fan In ATMOSPHERE
Volts T1-T3 NA Fan Out NAC
TEF-1B 2018-11-27
KEH-2 KITCHEN EXHAUST HOOD. MAKE
EXHAUST E MAKE-UP AIR CONNECTIONS
PER SCHEDULE t CAPTIVE AIRE
PSD 1360. 10". SA UP. DRAWING=S. REFER TO 1-422 FOR
(TYP OF 4) CONTINUATION ABOVE 4 DUCT SIZES.
L-- _ aHi
111 O Ii
la
W U1 v w
Z
}
111 h
o z W
LL (0 0 W
n.(i
• 0
- z 6 l If
n KW _, _ 7
CQI fJ cj rftca
r -� - W
1 11111
• L i _ _ ACL ( a
I 11.11 I PROVIDE WALL FURRING FROM SINK FIT TO ®
c‘\
67 at
ilimm O _ I _ FLUOR TO RUN WATER AND DRAIN PIPING
I o — — • IN HEATED WALL SPACE Seal 3
0
e
i-
n LI
IlrCI i -:-.. II 6"m - r,-- (E) EA 3
614,
L.,—: - - ai 1361...... ..i.
J w❑M: toipi�IIflllu�llfl�l-I�� - - it
9�:`\ . .eii II � � _ _ � I $IIIII• i C , ° • ici
O•� ELECTRIC CEILING HEATER (TYP.)
■ o Illj ;, Q to
5 z
ll‘r
�_ �� �!r—>a! ' azo. ik
IID 0
lam + '�� II■i11�LICi. O® . . �' �I I - - co
lit, - --, ® ins - o
23 —1W 1111 e„
-.-.-...-Jr•-arTa - i_ la— f I<
Liczatitiorratauli 1
-'a_� I `` 1 r �� ME�'S TOILET 1 � - K
lal _ ak, 110 es"- It ._, : ww
I Illir
station Ikt1.JD2 ±!Li
I 1121
in DN II W
In I 02
15:4 04 41 2-l'ami ° 6
D
2 ,_ al
��
II �!,,� BAR
r=== =I �1 [i n -I= T EFl1 H
< 1"I °-1 4.....------ IA nr-- - - i ingq MA cii) >.
' o IA
7 /Sri milm A (Li . EL., _ -
O
SCHEDULE t CAPTIVE AIRE DRAWINGS. - IN DINING ROOM t r 1 N
REFER TO H22 FOR CONTINUATION ABOVE f V Er
n
t DUCT SIZES. L t _ n _� �� W Z
moi— " __
— o ` `I W
II <wis __,_ _ _ L NM Z
Z• 111W 41)
z. EBB-6 O r — z 111
2
>1.
o e
PSp-1 600. 12"m SA UP. �� `� 0
(TYP OF 3) L -n G -I 4 to
WW +-
,' LV4EA 1111k IK -R'
4r
AI WI-
W
Issued For z• tu
No. Date Comment ,LU ft
' `/ \/..•.\ / ` \ I 5/16/S PERMIT SS SET W IL
16" SA FROM MAU-I ABOVE. ROUTE INTO EEsB-8 �` _- 2 8/21/18 PERMIT SET � �
DROPPED CEILING= IN FRONT OF HOOD, / 3 6/22/IS REVISION I
CONNECT TO DIFFUSERS. FIELD i 01-
AND
COORDINATE DUCT ROUTINGS- lI - q p
} z
II LOCATE ON HIGH SIDEWALL - Egg-S 4
II I A$OVE LOWER DINING
III ROOF. Q
III, /� T 1°4(i.
s
III,III h ' 1 T 1 TOWER DINING it p
12"m EA UP. EBB-S ROOM 0
/����� RE: H2.2 a
4/4444*
/ it-744-: — I-- _,
`/`� �\ \ 4 i
`/`7�����/�j MAIN !-EVI=L W
_=
HVAC PLAN W (X
• in Z
I I� �I I _
\ it
Hi
0
o. Scale:DrawnBy:
MAIN LEVEL HVAC PLAN BJH JDR N z 0
„.,
re
SCALE: 1/4" = 1'-0" zHi
In
an=
pcit:
IU o1
111 O tuW
�\\ NI- O
',lee Z Ul
z
\ \ \ (0 (3 i
0 u
.4 ta o
LD�� _ t
L �Z Q � d to
I- J INSTALL FOR OFFICE cAf3LE LY. TERMIN OPERATED
MANUA!DAMPER 1 L 01 cd C• . i
DN i
OPERAACCESTOR AT SUPPLY GRILLE FOR EASY ®' O 13 z
COORDINATE EXACT MAU-1 DUCTING LAYOUT WITH I ' ' ® sr 61 w
I-
OWNER 4 CHEF PRIOR TO INSTALLATION, TO INSTALL GREASE DUCT LOIN ROOM, ON FLOOR, ft
W
MAXIMIZE USEABLE STORAGE SPACE. - AS REQUIRED. GENERAL CONTRACTOR TO BUILD Seal 3
CUSTOM PROTECTIVE ENCLOSURE AROUND I-
1 -3 1 GREASE DUCT (WITH ACCESS TO CLEAN-OUT). 0
cop �G����
Tf lr- ~
A T I T j JCEF-1 KITCHEN EXHAUST FAN (TYPE I, GREASE), 3
A B❑V. MOUNTED ON ROOF CURS ABOVE. DEMO EXISTING w
DISH AR' • ROOF HATCH GREASE FAN 4 CURB. to
IIIIII IIII IIII IIII IIII IIIIII --
• . ❑M r T V V V V V V V ;.,■r�rif�} �j��jTJIi
IMPORTANT: EXISTING INTAKE LOUVER SCREEN IS r��
BLOCKED WITH DEBRIS. MECHANICAL I — OL .� 20/20 TYPE I GREASE DUCT, WRAPPED q r
CONTRACTOR SHALL CLEAN ANp/oR REPLACE J L �� Wine EXTERNALLY WITH FIRE WRAP (RE: SPECS). DEMO - Z
EXISTING SCREEN. ( I �� 20!20 r�� S
landing 1 EXISTING GREASE DUCT 4 WRAP. SLOPE ALL in 0
. ml �r I ,ICO DUCTWORK BACK TOWARDS HOOD PER CODE. N U
' DN 4C4z
'4 Frer/777/F — ..c _ _, I \l/
?' / MID LEVEL I- ft
CEJ LV-la OA-� gZ (T)
1 /
ft
1 __ O
V r L_ L _I 11 I DN _ to w
j` I
.HARED SERVICE AREA] 'CLEAR.NEC ' 1
_ -- — 13.41-1 O IL o
PI L _ JI I I 0 --� C� w di a
(N) LV-Ib OA-� •
• � I 10/6 '! " - p (K
JØ,6A1J.1 ST❑RAGE AREA ,�AA
EA
f EVAP BURNER BLOWER' 94, 10/6 RUN OUT (TYPJ BAR BELOW 9 2 J F-
/ + ^ 0
/,� / IL Irl:. - tI �io
Q z
NEW INTAKE LOUVER TO MATCH EXISTING LOUVER ft I. i .i_- - _ -:1 j� _ •I ^ al -4
AND BE INSTALLED SYMMETRICALLY TO ROOF I I I I IK
RIDGE. I I I rO� I- z
I I U u a
18/18 (UNLINED, OA) CONNECT TO I c5 ,
LOUVER HIGH, WRAP WITH 2" OF I I w Q• :
DUCT WRAP, (RE: SPECS) I
(tip OF2) MAI DIING BELOW i Sill
I I _� U If4-
36/42 (UNLINED, OA). WRAP WITH 2" I I
4). n di
OF DUCT WRAP, (RE: SPECS) I I 9 I I0 ~� r u z
I _ �'i N z II
36/42 AIR FILTER SECTION (Si) FPM FACE VELOCITY). —I I I I 0
tow
PROVIDE CUSTOM SHEET METAL FILTER BOX WITH 1� _ w
REMOVABLE ACCESS COVER FURNISH FILTERS IN 4 • w z
SECTIONS FOR EASY REPLACEMENT. FILTERS SHALL BE 2" .sI \ / I- r,
THICK, SPUN FIBERGLASS TYPE (LOU PRESSURE DROP). LJ \\\\ //// CEF-I COOLING EXHAUST FAN- at gO
ill
- - - -- --
\ \ / / PROVIDE ACCESS. Q to
MAU-I KITCHEN MAKE-UP AIR UNIT. HANG \\\\ // 0
FROM CEILING WITH UNI-STRUT, THREADED \ / / CZ it
ROD, 4 SPRING VIBRATION ISOLATORS- \ / / "
PROVIDE ACCESS. USE FLEXIBLE - \ \ / / w 4-
ROUTE 12 � EA DUCT UP TO 24" BELOW
CANVAS CONNECTORS AT BOTH INTAKE 4 \ \ / / PEAK OF ROOF AND COVER OED WITH WIRE z W
DISCHARGE OF UNIT. REVIEW ALSO .� / / — MESH. Issued For W
OPTION OF LOCATING UNIT ON FLOOR, / / I w 0
MOUNTED ON HOUSED SPRING VIBRATION \ \ / / No. Date Comment
ISOLATORS. / N\\ //// I 5/l6/IS PROGRESS SET to W
\., / / - 2 5/21/18 PERt'1IT SET I- w
— / v U / `�0 \ \\ // 3 6/22/18 REVISION 1 CO
Y \ \ / /
16" SA DOWN TO DIFFUSERS IN FRONT OF
/ / "Tit a
HOOD. INCLUDE VOLUME DAMPER FOR ii i \ x / >• Q
AIR BALANCING. \ X X r
/ X \
1 / / \ \ Q li
it / / \ \ z }
///T'OWER DININN\'RQ❑M � - w p
l\\. //// BELOW •\\\\
i / /% / / \ \ Q
�/% / / v v _ o z
1 / / \ \ r 0
�i= €
\/`-�--7,../..>,,_ //// \\\\ 0 0
/ / \ \ 2
/��-75,74,4.1-74t,,,,,_,_
� / / \ \ 4 Lu
/�/���� //// \\\\ UPPER LEVEL w w
/% ----- /// - \\\
/ I-IVAC PLAN i w z
U � LI • _IW
ID
at 6 v
4 In
NORTH w w w
Project No. Scale: W z 1
18004.00 1/4" = 1'-0" o U
Drawn By: Checked By: z z W 0
UPPER LEVEL HVAC PLAN aJH JDR w z 0
z9FY.
SCALE: 114" = 1'-0" i w
Q
U w 0
U
Q ®